| 头/盘接触状态下润滑剂迁移行为研究 |
| |
| 引用本文： | 潘登,唐正强,郝秀红. 头/盘接触状态下润滑剂迁移行为研究[J]. 西南交通大学学报, 2018, 53(4): 829-834. DOI: 10.3969/j.issn.0258-2724.2018.04.022 |
| |
| 作者姓名： | 潘登 唐正强 郝秀红 |
| |
| 作者单位： | 燕山大学机械工程学院;贵州大学机械工程学院 |
| |
| 基金项目： | 国家自然科学基金资助项目51505093河北省自然科学基金资助项目E2016203206 |
| |
| 摘 要： | 为了提高磁头飞行稳定性，增加硬盘使用寿命，基于分子动力学方法建立了磁头磁盘接触状态下的润滑剂迁移模型.根据硬盘工作时磁头磁盘的相对移动速度及磁头在盘片表面飞行时高、低压区域压力差的范围，采用所建立模型分析了相对移动速度及高、低压区域压力差对润滑剂迁移及在盘片表面分布的影响；此外，通过调节模型中单个润滑剂分子的粒子数得到不同长度的润滑剂分子碎片，并分析润滑剂分子碎片对润滑剂迁移的影响。研究结果表明:磁头磁盘之间的润滑剂转移随着相对移动速度及高、低压区域之间压力差的增大而增大.润滑剂转移量在单位压力及单位速度下的增长率分别约为38.8%和6.7%；润滑剂分子碎片对磁头磁盘之间的润滑剂转移影响很小；润滑剂在盘片表面堆积的高度随着磁头磁盘相对移动速度的增加而降低；高、低压区压力差的变化对润滑剂在盘片表面堆积的高度没有影响.
|
| 关 键 词： | 润滑剂转移 分子动力学模拟 盘片速度 硬盘 |
| 收稿时间： | 2017-04-18 |
Investigation of Lubricant Transfer under Slider Lubricant Contact Condition |
| |
| PAN Deng,TANG Zhengqiang,HAO Xiuhong. Investigation of Lubricant Transfer under Slider Lubricant Contact Condition[J]. Journal of Southwest Jiaotong University, 2018, 53(4): 829-834. DOI: 10.3969/j.issn.0258-2724.2018.04.022 |
| |
| Authors: | PAN Deng TANG Zhengqiang HAO Xiuhong |
| |
| Abstract: | To enhance slider flying stability and extend the life span of hard-disk drives, a molecular dynamics model for investigating lubricant transfer in the presence of slider lubricant contact was built. The effects of the following parameters on lubricant transfer and lubricant distribution on the disk surface during the operation of the hard-disk drive were analysed:relative velocity between the slider and disk and the range of the air-bearing pressure difference between the high-and low-pressure areas before contact. In addition, lubricant fragments with different lengths were obtained by adjusting the number of beads within a full lubricant molecule. The effect of lubricant fragments on lubricant transfer was also investigated. The simulation results indicate that the amount of lubricant transfer increases with increasing slider-to-disk relative velocity and air-bearing pressure difference; the growth rates of the amount of lubricant transfer are 38.8% and 6.7% for unit air-bearing pressure and unit velocity, respectively. Lubricant fragments have little effect on lubricant transfer; the height of lubricant accumulation decreases with increasing relative velocity. The lubricant accumulation height on the disk surface is not affected by the air-bearing pressure difference. |
| |
| Keywords: | |
| 本文献已被 CNKI 等数据库收录！ |
| 点击此处可从《西南交通大学学报》浏览原始摘要信息 |
|
点击此处可从《西南交通大学学报》下载免费的PDF全文 |
